Norton Commando
Jerrydoe.com  Forum Home  Norton Commando Forum  Photos  [FAQ]  [Search]  [Memberlist]   
 [Profile]  [Check your private messages]  [Register]  [Log in] 
Introduction / Tires / Lucal Switchgear

 
Post new topic   Reply to topic    Norton Commando Forum Index -> Norton Commando Motorcycles.
View previous topic :: View next topic  
Author Message
Guest
Guest





PostPosted: Tue Nov 09, 2004 8:53 pm    Post subject: Introduction / Tires / Lucal Switchgear Reply with quote

Greetings. I have just retrieved my 1974 licensed Norton from may family's property. It was last registered in 1985. It is either a roadster with interstate tank and seat or interstate with roadster side panels and pipes/mufflers.
I am in the process of getting it back on the road. I just had a new K81 tire mounted on hte front wheel - I have tried unsuccessfully to mount tyres in the past and believe it is a matter best left to those in the know. However, when I returned with the newly clad tyre discovered that the arrow indicating the direction for the front wheel was backwards. I have never used this shop before and I anticipate a battle with them saying that it doesn't make a difference. can you, please, advise.
Also, My disk brake puked its fluid over the right Lucas switchgear. I have rebuilt the caliper & master cylinder, but I recall, years ago, that the Lucas switchgear cannot be serviced. It appears to be possible to pull it appart for cleaning, but am I in for a nightmare of springs dancing all over the workshop? Any recommendations?
With best regards,
Todd Stenson - Minnesota USA
Back to top
bill



Joined: 01 Jun 2003
Posts: 135
Location: Orlando Fl/Shady Valley Tn.

PostPosted: Wed Nov 10, 2004 3:59 am    Post subject: Reply with quote

todd

if your tire ( tyre ) installer gives you a hard time than ask him if he knows more than dunlop!! the arrow's are there for the direction of load ie frount under braking rear accelaration and would like a law suit if I get hurt because you refused to mount it the proper way!!! if he does not fix it in a nice way than find a new shop.

the switch gear is not to bad to take apart but there is a few little springs. just do it in a clean open area so if you drop a spring you can find it and do it over a towel so they dont roll to far.

bill
Back to top
MichaelB



Joined: 14 Jan 2004
Posts: 446
Location: Yorba Linda, CA

PostPosted: Wed Nov 10, 2004 6:55 am    Post subject: Reply with quote

Todd,
Bill is correct. Tire manufacturers design the tires for the proper rotation. Any reputable tire shop will know this. This could be an honest mistake because the 75 has the disc on the left which would dictate a different mounting. Approach it diplomatically and show him your disc is on the right, therefore it is incorrect. I bet he changes it right away.
Back to top
debby



Joined: 15 Apr 2004
Posts: 898
Location: Boulder, CO

PostPosted: Wed Nov 10, 2004 8:05 am    Post subject: Reply with quote

Timely topic for me. I'm about ready to switch over to the disk so I need to remove my K81 from the drum brake wheel and mount it on the new wheel.

As bill alluded to above, I thought the tire was supposed to be mounted one way for the front and the other way for the rear? If so does the arrow indicate the correct orientation for the rear wheel or for the front?

Debby
Back to top
MichaelB



Joined: 14 Jan 2004
Posts: 446
Location: Yorba Linda, CA

PostPosted: Wed Nov 10, 2004 8:29 am    Post subject: Reply with quote

Debby, It is clearly marked Front rotation and rear rotation on opposite sides of the tire.
Back to top
Todd
Guest





PostPosted: Wed Nov 10, 2004 10:30 am    Post subject: Reply with quote

Thanks very much, people. I just spoke with the shop and they will change the tyre around. They were very nice about it.
This is a great list. I have learned a lot.
Back to top
Display posts from previous:   
Post new topic   Reply to topic    Norton Commando Forum Index -> Norton Commando Motorcycles. All times are GMT - 8 Hours
Page 1 of 1

 
Jump to:  
You cannot post new topics in this forum
You cannot reply to topics in this forum
You cannot edit your posts in this forum
You cannot delete your posts in this forum
You cannot vote in polls in this forum

The Unapproachable Norton Commando

At the end of 1967 the Norton Commando was announced.

The Norton Commando was greeted with a certain amount of scepticism because on first sight the commando appeared to comprise of the old Norton Dominator twin cylinder engine mounted at an inclined angle in a set of new cylinder parts.

It was not realized that the new Norton Commando Isolastic method of engine suspension damped out all engine vibration and produced a machine which had uncanny smoothness for a vertical twin. In due course the critics were silenced and the Norton Commando had the distinction of being regarded as the first of todays so called superbikes. There can be little doubt that the original design concept of the Norton Commando has proved correct, since comparatively few modifications of any real consequence have been made since production commenced during 1968.

Now nearly 40 years later Norton Commando riders like us are a breed of our own, and as far as we are concerned its still more fun to go for a blat on the old Norton Commando, and fast. As a Norton Commando owner and enthusiast, my goal here is to promote and give credit to those who keep the Norton name going.

It is more deserving to give credit to the Commando itself, for after all these years it continues to be respected. The original Commando designers like John Favill are those who deserve the credit for developing this incredible motorcycle.

The Norton Commando Roadster and Interstate of the late seventies, never died. Although the Norton Villiers factory dispersed the tradition lived on. Today Kenny Dreer in the USA is developing the new 952 CC Norton. What a great looking bike this is, and its engineering is still based on the original layout. It will be interesting to see how the new 952CC Norton does in todays tough motorcycle market. One thing is for sure, I would own one if I could afford it.